How to Install A/C Hose for Underbody Refrigerant Lines on Chrysler Town & Country?

Position the underbody refrigerant lines into the brackets that hold them and secure them using bolts. Take any tape or plugs out of the connections on the underbody refrigerant line and both front extension lines. Add a little refreigerant oil to the rubber seal rings and set them into the underbody refrigerant fittings. To connect, fit the A/C liquid and suction front extension lines to the car's refrigerant lines below it and use a torque wrench to tighten each fitting to 23 Nm (17 ft.lbs.). Should the underbody suction rear extension line be disconnected, set it into the refill pipe and clip it on with the nylon strip. Take off the tape or plugs in the underbody refrigerant and extension line fittings, as well as the expansion valve at the rear, then apply clean refrigerant oil to the new rubber O-ring seals and set them on the underbody fittings, ensuring the seals and oil used are those recommended. Connect the underbody refrigerant rear extension lines to the sealing plate and briefly attach the holding nut to the rear A/C expansion valve. Hook the underbody rear extension tubes to the underbody refrigerant tubes, securing them with a torque of 23 Nm (17 ft.lbs.) and afterwards tighten again the nut connecting the rear A/C expansion valve's rear lines and metal sealing housing to 23 Nm (17 ft.lbs.). Put the exhaust system in place and fasten it to the rubber hanger isolators, take the vehicle down, reconnect the negative battery wire, remove the refrigerant and finally charge the refrigerant.

How to Remove the A/C Hose Suction Line on Chrysler Town & Country?

Before you remove the A/C suction line, disconnect the negative battery cable and isolate it. Take out the refrigerant from the refrigerant system. Then, take the air cleaner housing and its inlet duct off from the engine compartment. First, remove the bolt that connects the A/C suction line to the A/C compressor and then take apart the A/C suction line from the compressor, tossing out the O-ring label and gasket. Take off the bolt that holds the A/C suction line to the right front frame rail. For vehicles with a rear-mounted heating-A/C unit, loosen the fitting nut, take off the A/C suction extension line from the A/C suction pipe and take out the O-ring. Should these bolts be present, remove the bolt that holds the suction line bracket to the strut tower. Take away the nut that fastens the suction and liquid lines to the A/C expansion valve and separate both lines from the valve, wiping out the washer seals. Take out the A/C liquid line at the tapping block on the A/C suction line and open up the A/C suction line from the dash brackets in the center as well as from the rear of the receiver/drier. After that, pull the A/C suction line from the engine compartment and cover up or seal all opened refrigerant line fittings and the compressor and expansion valve ports with plugs.

OEM Chrysler Town & Country A/C Hose

Air Conditioning Hose

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

56 A/C Hoses found

View related parts
Chrysler Town & Country Liquid Line Part Number: 68142912AA
$50.78 MSRP: $112.00
You Save: $61.22 (55%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Line - A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Line A/C Liquid Includes: O - Rings
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2012-2016 Chrysler Town & Country | 30th Anniversary Edition, LX, Limited, Limited Platinum, S, Touring, Touring L | 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Chrysler Town & Country Suction Hose Part Number: 68142915AA
$202.81 MSRP: $301.00
You Save: $98.19 (33%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Line - A/C Suction; A/C Refrigerant Suction Hose; A/C Refrigerant Liquid Hose; A/C Hose; Line A/C Suction Includes: Gaskets, Seals, Charge Valve, Valve Cap
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2012-2016 Chrysler Town & Country | 30th Anniversary Edition, LX, Limited, Limited Platinum, S, Touring, Touring L | 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Chrysler Town & Country A/C Line Part Number: 68142911AA
$115.96 MSRP: $174.00
You Save: $58.04 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Line - A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Liquid Line; Line A/C Liquid Includes: O - Rings
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2012-2016 Chrysler Town & Country | 30th Anniversary Edition, LX, Limited, Limited Platinum, S, Touring, Touring L | 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Chrysler Town & Country Discharge Hose Part Number: 5005241AA
$43.04 MSRP: $61.85
You Save: $18.81 (31%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Line - A/C Discharge; A/C Refrigerant Discharge Hose; A/C Refrigerant Liquid Hose; A/C Hose; A/C Hoses; Line A/C Discharge
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2005 Chrysler Town & Country | Base, EL, EX, LX, LXi, Limited, Touring | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country A/C Hoses Part Number: 5066517AA
$83.57 MSRP: $105.94
You Save: $22.37 (22%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Line - A/C; A/C Refrigerant Liquid Hose; A/C Hose; Liquid Line; Line A/C Liquid To Expansion Valve
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2007 Chrysler Town & Country | Base, LX, Limited, Touring | 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country Discharge Hose Part Number: 4677492AG
$46.39 MSRP: $99.80
You Save: $53.41 (54%)
ADD TO CART
Product Specifications
- Other Name: Line - A/C Discharge; A/C Refrigerant Discharge Hose; A/C Refrigerant Liquid Hose; A/C Hose; A/C Hoses
- Replaces: 4677492AD, 4677492AC
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2005-2007 Chrysler Town & Country | Base, LX, Limited, Touring | 3.3L V6, 3.8L V6, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country A/C Hoses Part Number: 4677164
$69.72 MSRP: $127.00
You Save: $57.28 (46%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Line - A/C Suction; Suction Hose; Line Assembly, Suction; Line A/C Suction
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-1997 Chrysler Town & Country | Base, LX, LXi, SX | 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country A/C Hoses, Front Part Number: 4677481AE
$170.94 MSRP: $286.00
You Save: $115.06 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Line - A/C Suction; A/C Refrigerant Suction Hose, Front; A/C Refrigerant Liquid Hose; A/C Hose; Suction Hose; Line A/C Suction
- Position: Front
- Replaces: 4677481AD
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2005-2007 Chrysler Town & Country | Base, LX, Limited, Touring | 3.3L V6, 3.8L V6, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country A/C Hoses Part Number: 5139220AA
$57.78 MSRP: $95.25
You Save: $37.47 (40%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Line - A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Liquid Line; Line A/C Liquid To Condenser
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2005-2007 Chrysler Town & Country | Base, LX, Limited, Touring | 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country A/C Hoses Part Number: 4796561
Product Specifications
- Other Name: Line - A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Liquid Line; Line Assembly, Liquid; Line A/C Liquid
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-2000 Chrysler Town & Country | Base, LX, LXi, Limited, SX | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country A/C Hoses Part Number: 5066523AA
Product Specifications
- Other Name: Line - Auxiliary A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Liquid Line; Line Auxiliary A/C Liquid; Line A/C Liquid
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2005 Chrysler Town & Country | Base, EL, EX, LX, LXi, Limited, Touring | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country A/C Hoses Part Number: 5066506AA
Product Specifications
- Other Name: Line - A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Liquid Line; Line A/C Liquid To Condenser
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2004 Chrysler Town & Country | Base, EL, EX, LX, LXi, Limited, Touring | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country Liquid Line Part Number: 68125528AA
Product Specifications
- Other Name: Line - Auxiliary A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Line Auxiliary A/C Liquid
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2011 Chrysler Town & Country | Limited, Touring, Touring L | 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Chrysler Town & Country Liquid Line Part Number: 68029280AA
Product Specifications
- Other Name: Line - A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Line A/C Liquid Includes: O - Rings; Line A/C Liquid
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008-2011 Chrysler Town & Country | LX, Limited, Touring, Touring L, Touring Plus, Walter P. Chrysler Signature Series | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Chrysler Town & Country A/C Line Part Number: 68125526AA
Product Specifications
- Other Name: Line - A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Liquid Line; Line A/C Liquid Includes: O - Rings
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2011 Chrysler Town & Country | Limited, Touring, Touring L | 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Chrysler Town & Country Discharge Hose Part Number: 4677492AA
Product Specifications
- Other Name: Line - A/C Discharge; A/C Refrigerant Discharge Hose; A/C Refrigerant Liquid Hose; A/C Hose; Line A/C Discharge
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2004 Chrysler Town & Country | Base, EX, LX, Limited, Touring | 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chrysler Town & Country Suction Line Part Number: 68029285AA
Product Specifications
- Other Name: Line - Auxiliary A/C Suction; A/C Refrigerant Suction Hose; A/C Refrigerant Liquid Hose; A/C Hose; Line Auxiliary A/C Suction Includes: O - Rings; Line A/C Suction Includes: O - Rings; Line A/C Suction
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008-2010 Chrysler Town & Country | LX, Limited, Touring, Touring Plus, Walter P. Chrysler Signature Series | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Chrysler Town & Country Suction Hose Part Number: 68029283AA
Product Specifications
- Other Name: Line - A/C Suction; A/C Refrigerant Suction Hose; A/C Refrigerant Liquid Hose; A/C Hose; Line A/C Suction Includes: Gaskets, Seals, Charge Valve, Valve Cap; Line A/C Suction
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008-2010 Chrysler Town & Country | Limited, Touring, Touring Plus | 6 Cyl 4.0 L GAS
View related parts
Chrysler Town & Country A/C Line Part Number: 68029278AA
Product Specifications
- Other Name: Line - A/C Liquid; A/C Refrigerant Liquid Hose; A/C Hose; Line A/C Liquid Includes: O - Rings; Line A/C Liquid
- Replaces: 68029290AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008-2010 Chrysler Town & Country | LX, Limited, Touring, Touring Plus, Walter P. Chrysler Signature Series | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Chrysler Town & Country Discharge Hose Part Number: 4677340AB
Product Specifications
- Other Name: Line - A/C Discharge & Liquid; A/C Refrigerant Liquid Hose; A/C Hose; A/C Hoses
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1993 Chrysler Town & Country | Base | 6 Cyl 3.3 L GAS

| Page 1 of 3 |Next >

1-20 of 56 Results

Chrysler Town & Country A/C Hose

Choose OEM A/C Hose that meet Chrysler factory standards. Chrysler designs and tests every component for precision and durability. Each A/C Hose follows strict manufacturing steps to lock in quality and fit. If your Chrysler Town & Country matters to you, OEM parts make the smart choice. You'll get the exact look, feel, and performance you expect. Shop genuine Town & Country parts at the highly competitive prices online. Enjoy a manufacturer's warranty, a hassle-free return policy, and rapid delivery. No more guesswork with off brands. Get genuine parts with exact fit and true factory performance. Shop with confidence today at JeepPartsDeal.com.

There is similar well-known product known as the Chrysler Town & Country A/C Hose, which is employed in the air conditioning structure of the vehicle efficiently. This A/C Hose aids in conveying Refrigerant, helps in cooling the cabin and therefore delivers comfortable usage of the vehicle. Constructed to endure the pressures in gaseous state of a refrigerant, the Chrysler Town & Country A/C Hose affords the car safety and efficiency as its aluminum ends come with crimped portions to avoid leakage. Support for numerous models of the Chrysler Town & Country means that drivers can always achieve the premier result regardless of the minivan's generation. Thus, it is vital for the A/C Hose to work as a continuous channeling of the refrigerant for the vehicle's ability to maintain comfort within the interior of a car. Further, the Chrysler Town & Country A/C Hose is significantly unique in the automotive market due to hard, wearing construction and numerous patterns that increase the life cycle and performance. They act as a go-to model line of Chrysler and it is for this reason that the Town & Country A/C Hose has been on par with the changes of the model over the years, and therefore it can be vouched for that it is reliable. Last but not least, Chrysler Town & Country A/C Hose not only help in the determining the performance of the vehicle but also help in the safety and comfort of all passengers.

Chrysler Town & Country A/C Hose Parts and Q&A

A/C Hoses
5066517AA
Q: How to Install A/C Hose for Underbody Refrigerant Lines on Chrysler Town & Country?
A:
Position the underbody refrigerant lines into the brackets that hold them and secure them using bolts. Take any tape or plugs out of the connections on the underbody refrigerant line and both front extension lines. Add a little refreigerant oil to the rubber seal rings and set them into the underbody refrigerant fittings. To connect, fit the A/C liquid and suction front extension lines to the car's refrigerant lines below it and use a torque wrench to tighten each fitting to 23 Nm (17 ft.lbs.). Should the underbody suction rear extension line be disconnected, set it into the refill pipe and clip it on with the nylon strip. Take off the tape or plugs in the underbody refrigerant and extension line fittings, as well as the expansion valve at the rear, then apply clean refrigerant oil to the new rubber O-ring seals and set them on the underbody fittings, ensuring the seals and oil used are those recommended. Connect the underbody refrigerant rear extension lines to the sealing plate and briefly attach the holding nut to the rear A/C Expansion Valve. Hook the underbody rear extension tubes to the underbody refrigerant tubes, securing them with a torque of 23 Nm (17 ft.lbs.) and afterwards tighten again the nut connecting the rear A/C expansion valve's rear lines and metal sealing housing to 23 Nm (17 ft.lbs.). Put the exhaust system in place and fasten it to the rubber hanger isolators, take the vehicle down, reconnect the negative battery wire, remove the refrigerant and finally charge the refrigerant.
Discharge Hose
4677577AC
Q: How to Remove the A/C Hose Suction Line on Chrysler Town & Country?
A:
Before you remove the A/C suction line, disconnect the negative battery cable and isolate it. Take out the refrigerant from the refrigerant system. Then, take the air cleaner housing and its inlet duct off from the engine compartment. First, remove the bolt that connects the A/C suction line to the A/C compressor and then take apart the A/C suction line from the compressor, tossing out the O-ring label and gasket. Take off the bolt that holds the A/C suction line to the right front frame rail. For vehicles with a rear-mounted heating-A/C unit, loosen the fitting nut, take off the A/C suction extension line from the A/C suction pipe and take out the O-ring. Should these bolts be present, remove the bolt that holds the suction line bracket to the strut tower. Take away the nut that fastens the suction and liquid lines to the A/C Expansion Valve and separate both lines from the valve, wiping out the washer seals. Take out the A/C liquid line at the tapping block on the A/C suction line and open up the A/C suction line from the dash brackets in the center as well as from the rear of the receiver/drier. After that, pull the A/C suction line from the engine compartment and cover up or seal all opened refrigerant line fittings and the compressor and expansion valve ports with plugs.