How to Remove the ABS Control Module on Dodge Grand Caravan?

To take out the Hydraulic Control Assembly on a right-hand drive car, first cut the negative cable from the battery and disengage it. Set your brake pedal depressor to keep the pedal locked in place beyond its first inch of travel to keep the master cylinder from draining its fluid. Lift the vehicle and take off the routing clip that links the ICU wiring harness to the ICU bracket. Do not put a 12-volt power source on any of the HCU connector's terminals when disconnected. Open the 24-way connector on the CAB by holding the lock and drawing it out. Use Mopar Brake Parts Cleaner to clean all parts of the HCU and brake tube nuts. After that, remove the brake tubes from the inlet and outlet ports. With three bolts out of the front suspension crossmember, you can remove the ICU and its bracket as a unit. Open the ICU from the mounting bracket by taking out the three bolts. Position the ICU over the mounting bracket and hold it in place using bolts that you tighten to 11 Nm (97 in. lbs.). The ICU mounting bracket to the front suspension crossmember should only be held in place by original or Mopar bolts which must be torqued to 28 Nm (250 in. lbs.). See that the brake tubes are installed both straight and separate from each other and from any another components and then reattach the spacer clips. Insert the six brake tubes of the chassis into their proper holes on the HCU valve block and tighten all the tube nuts to 17 Nm (145 in. lbs.). Before connecting the 24-way connector to the CAB, make sure the seal is in place. Slide the connector into the CAB socket and lightly press it. After that, press down on the lock button. Connect the CAB wiring harness securely to the ICU bracket to keep it clear of the brake tubes and the rest of the car. Use the routing clips to renew the installation of the brake tubes, lower the vehicle, reattach the negative battery cable, bleed the base and ABS hydraulic systems and perform a test drive to check both systems.

How to Install the ABS Control Module on Dodge Grand Caravan?

The first step to install the Anti-Lock Brake System Module is to clean any debris from the matching surfaces on the HCU and ABM. Never use any kind of lubricant when installing either O-rings or solenoid valve stem seals. Each solenoid valve stem seal should be replaced if they're old, because they might allow moisture and dirt into the solenoid valve if you use them again. If the pump/motor connector O-ring is not new, swap it out and set it in the groove where it belongs. Connect all the pieces and carefully put the ABM on the HCU, then connect it with four screws, tightened to 2 Nm (17 in. lbs.). It is necessary to have the rubber seal correctly fitted in the connector before fitting the ABM harness connector. Put the ABM wiring harness connector into the socket of the ABM and shut the cover to keep it securely locked. Fix the negative cable to the negative terminal of the battery. After that, use the scan tool to start the ABM, remove any faults, finish the ABS Verification Test and test the car on the road.

OEM Dodge Grand Caravan ABS Control Module

Anti Lock Brake Control Module

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

19 ABS Control Modules found

View related parts
Dodge Grand Caravan Modulator Valve Part Number: 68030938AA
$927.45 MSRP: $1375.00
You Save: $447.55 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Master Cylinder - Anti-Lock Brake System; ABS Hydraulic Assembly; ABS Control Module; Modulator; Hydraulic Control Unit Anti-Lock Brake System
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008-2010 Dodge Grand Caravan | C/V, SE, SXT | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Dodge Grand Caravan Modulator Valve Part Number: 68214374AA
$783.45 MSRP: $1200.00
You Save: $416.55 (35%)
ADD TO CART
Product Specifications
- Other Name: Module - Anti-Lock Brake; ABS Hydraulic Assembly; ABS Control Module; Modulator
- Replaces: 68128173AC, 68128173AB, 68128174AA, 68128173AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2012 Dodge Grand Caravan | Crew, R/T, SE, SXT | 3.6L V6, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Dodge Grand Caravan Modulator Valve Part Number: 68194483AE
$1128.67 MSRP: $1605.00
You Save: $476.33 (30%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Control - Anti-Lock Brake; ABS Hydraulic Assembly; ABS Control Module; Modulator; Control Unit Anti-Lock Brake
- Replaces: 68194483AD, 68194483AB, 68194483AC
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2013-2020 Dodge Grand Caravan | American Value Package, Crew, GT, R/T, SE, SE 30th Anniversary Edition, SE Plus, SXT, SXT 30th Anniversary Edition | 3.6L V6, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 68030939AB
Product Specifications
- Other Name: Module - Anti-Lock Brake System; ABS Control Module
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008 Dodge Grand Caravan | C/V, SE, SXT | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Dodge Grand Caravan Modulator Valve Part Number: 5018252AA
Product Specifications
- Other Name: Accumulator - Anti-Lock Brake System; ABS Hydraulic Assembly; ABS Control Module; ABS Control Unit; Hydraulic Control Unit Anti-Lock Brake System
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2005 Dodge Grand Caravan | Anniversary Edition, Base, C/V, EL, ES, EX, SE, SE Plus, SXT, Sport | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 68089474AA
Product Specifications
- Other Name: Module - Anti-Lock Brake System; ABS Control Module; Module Anti-Lock Brake System
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2011-2012 Dodge Grand Caravan | C/V, Crew, Express, Mainstreet, R/T, SE, SXT | 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 5142248AA
Product Specifications
- Other Name: Control - Anti-Lock Brakes; ABS Control Module; Electronic Control; Module Anti-Lock Brakes With Mounting Screws; Module Anti-Lock Brakes
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2007 Dodge Grand Caravan | Base, SE, SXT | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 5013865AB
Product Specifications
- Other Name: Master Cylinder - Anti-Lock Brake; Electronic Control; Control Unit Package Anti-Lock Brake
- Replaces: 4882649AA, 5013865AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1997-2000 Dodge Grand Caravan | Base, ES, LE, SE, Sport | 2.4L L4, 3.0L V6, 3.3L V6, 3.8L V6, 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 5142251AA
Product Specifications
- Other Name: Control - Anti-Lock Brakes; ABS Control Module; Electronic Control; Module Anti-Lock Brakes With Mounting Screws; Module Anti-Lock Brakes
- Replaces: 5174110AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2005-2007 Dodge Grand Caravan | Base, SE, SXT | 3.3L V6, 3.8L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Modulator Valve Part Number: 5142246AA
Product Specifications
- Other Name: Accumulator - Anti-Lock Brake System; ABS Hydraulic Assembly; ABS Control Module; ABS Control Unit; Hydraulic Control Unit Anti-Lock Brake System
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2007 Dodge Grand Caravan | Base, SE, SXT | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 68053288AC
Product Specifications
- Other Name: Module - Anti-Lock Brake System; ABS Control Module
- Replaces: 68053288AB, 68053288AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2009-2010 Dodge Grand Caravan | C/V, SE, SXT | 3.3L V6, 3.6L V6, 3.8L V6, 4.0L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 5234955
Product Specifications
- Other Name: Module ABS Control Assembly; Modulator Valve; Intermittent Wiper; Fuse Block
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1991-1992 Dodge Grand Caravan | ES, LE, SE | 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L GAS
View related parts
Dodge Grand Caravan Modulator Valve Part Number: 5018253AA
Product Specifications
- Other Name: Accumulator - Anti-Lock Brake System; ABS Hydraulic Assembly; ABS Control Module; ABS Control Unit; Hydraulic Control Unit Anti-Lock Brake System
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2005 Dodge Grand Caravan | Anniversary Edition, Base, C/V, EL, ES, EX, SE, SE Plus, SXT, Sport | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Modulator Valve Part Number: 4882646
Product Specifications
- Other Name: Master Cylinder - Anti-Lock Brake System; ABS Control Module; ABS Control Unit; Hydraulic Control Unit Anti-Lock Brake System
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1997-2000 Dodge Grand Caravan | Base, ES, LE, SE, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 5013864AB
Product Specifications
- Other Name: Control - Anti-Lock Brake; ABS Control Module; Electronic Control; Control Unit Package Anti-Lock Brake
- Replaces: 4882648AB, 4882648AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1997-2000 Dodge Grand Caravan | Base, ES, LE, SE, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 5093986AA
Product Specifications
- Other Name: Control - Anti-Lock Brakes; ABS Control Module; Electronic Control; Module Anti-Lock Brakes With Mounting Screws; Module Anti-Lock Brakes
- Replaces: 5086174AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2005 Dodge Grand Caravan | Anniversary Edition, Base, C/V, EL, ES, EX, SE, SE Plus, SXT, Sport | 3.3L V6, 3.8L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Modulator Valve Part Number: 5142249AA
Product Specifications
- Other Name: Accumulator - Anti-Lock Brake System; ABS Hydraulic Assembly; ABS Control Module; ABS Control Unit; Hydraulic Control Unit Anti-Lock Brake System
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2007 Dodge Grand Caravan | Base, SE, SXT | 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Modulator Valve Part Number: 68089478AA
Product Specifications
- Other Name: Master Cylinder - Anti-Lock Brake System; ABS Hydraulic Assembly; ABS Control Module; Modulator; Hydraulic Control Unit Anti-Lock Brake System
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2011 Dodge Grand Caravan | C/V, Crew, Express, Mainstreet, R/T | 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Dodge Grand Caravan Control Module Part Number: 5093988AA
Product Specifications
- Other Name: Control - Anti-Lock Brakes; ABS Control Module; Electronic Control; Module Anti-Lock Brakes With Mounting Screws; Module Anti-Lock Brakes
- Replaces: 5086175AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2005 Dodge Grand Caravan | Anniversary Edition, Base, C/V, EL, ES, EX, SE, SE Plus, SXT, Sport | 3.3L V6, 3.8L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS

Dodge Grand Caravan ABS Control Module

Choose OEM ABS Control Module that meet Dodge factory standards. Dodge designs and tests every component for precision and durability. Each ABS Control Module follows strict manufacturing steps to lock in quality and fit. If your Dodge Grand Caravan matters to you, OEM parts make the smart choice. You'll get the exact look, feel, and performance you expect. Shop genuine Grand Caravan parts at the highly competitive prices online. Enjoy a manufacturer's warranty, a hassle-free return policy, and rapid delivery. No more guesswork with off brands. Get genuine parts with exact fit and true factory performance. Shop with confidence today at JeepPartsDeal.com.

The Dodge Grand Caravan ABS Control Module is a critical part that exemplify the reliability and power of the Dodge Grand Caravan series that has been manufacturing for the Minivan market since the conception of the series. This ABS Control Module is meant to improve safety by not allowing the wheels to lock during aggressive braking allowing the Dodge Grand Caravan to have proper grip on the road. In concert with wheel speed sensors and other components of the braking system, the ABS Control Module regulates the degree of pressing on the brakes accordingly and enhanced control of the vehicle's stopping point and handling. Types of Dodge Grand Caravan models which the ABS Control Module is suitable for span across different years, thus it's the best for any car owner who wants to always achieve optimized performance and safety of the automobile. Notably, modern derivatives of the ABS Control Module can also include additional facilities such as the electronic stability control and the traction control, which would enhance the performance as well as the safety features of the Dodge Grand Caravan even more. This dedication towards the innovative and reliable has established the Dodge Grand Caravan minivan as the family car. Easy on the pocket, comfy, spacious and safe - the Dodge Grand Caravan boasting of a high quality ABS Control Module for its exceptional performance makes it one of the best in the market for both drivers and its passengers.

Dodge Grand Caravan ABS Control Module Parts and Q&A

Modulator Valve
5018252AA
Q: How to Remove the ABS Control Module on Dodge Grand Caravan?
A:
To take out the Hydraulic Control Assembly on a right-hand drive car, first cut the negative cable from the battery and disengage it. Set your brake pedal depressor to keep the pedal locked in place beyond its first inch of travel to keep the master cylinder from draining its fluid. Lift the vehicle and take off the routing clip that links the ICU wiring harness to the ICU bracket. Do not put a 12-volt power source on any of the HCU connector's terminals when disconnected. Open the 24-way connector on the CAB by holding the lock and drawing it out. Use Mopar Brake Parts Cleaner to clean all parts of the HCU and brake tube nuts. After that, remove the brake tubes from the inlet and outlet ports. With three bolts out of the front suspension crossmember, you can remove the ICU and its bracket as a unit. Open the ICU from the mounting bracket by taking out the three bolts. Position the ICU over the mounting bracket and hold it in place using bolts that you tighten to 11 Nm (97 in. lbs.). The ICU mounting bracket to the front suspension crossmember should only be held in place by original or Mopar bolts which must be torqued to 28 Nm (250 in. lbs.). See that the brake tubes are installed both straight and separate from each other and from any another components and then reattach the spacer clips. Insert the six brake tubes of the chassis into their proper holes on the HCU valve block and tighten all the tube nuts to 17 Nm (145 in. lbs.). Before connecting the 24-way connector to the CAB, make sure the seal is in place. Slide the connector into the CAB socket and lightly press it. After that, press down on the lock button. Connect the CAB wiring harness securely to the ICU bracket to keep it clear of the brake tubes and the rest of the car. Use the routing clips to renew the installation of the brake tubes, lower the vehicle, reattach the negative battery cable, bleed the base and ABS hydraulic systems and perform a test drive to check both systems.
Modulator Valve
68030938AA
Q: How to Install the ABS Control Module on Dodge Grand Caravan?
A:
The first step to install the Anti-Lock Brake System Module is to clean any debris from the matching surfaces on the HCU and ABM. Never use any kind of lubricant when installing either O-rings or solenoid Valve Stem Seals. Each solenoid valve stem seal should be replaced if they're old, because they might allow moisture and dirt into the solenoid valve if you use them again. If the pump/motor connector O-ring is not new, swap it out and set it in the groove where it belongs. Connect all the pieces and carefully put the ABM on the HCU, then connect it with four screws, tightened to 2 Nm (17 in. lbs.). It is necessary to have the rubber seal correctly fitted in the connector before fitting the ABM harness connector. Put the ABM wiring harness connector into the socket of the ABM and shut the cover to keep it securely locked. Fix the negative cable to the negative terminal of the battery. After that, use the scan tool to start the ABM, remove any faults, finish the ABS Verification Test and test the car on the road.