How to Service the Fuel Pump and Gauge Sender on Dodge Ram 3500?

Before starting to service the fuel gauge sender, make sure the pressure from the fuel system is released, because it may remain at a constant level. Click the red handle to the right and pull the negative cable from the battery. Following this, disconnect and remove the fuel tank and blast away all dirt and particles near the opening using compressed air prior to removing the fuel pump module. Make a note of where the arrow is on the top of the fuel pump module. Put the notches in the lock ring on the car using the lock ring remover/installer 9340, then attach a 1/2 inch drive breaker bar to turn the lock ring counterclockwise. Replacing the rubber O-ring seal is necessary whenever you service the fuel pump module. Remove the fuel pump module from the fuel tank and double-check that the float arm is not bent as you do so. Then, throw out the old rubber O-ring seal.

How to Remove and Install a Fuel Pump on Dodge Ram 3500?

As the fuel transfer pump is known as the fuel lift pump, it is located on the left side of the engine and it is below and moving backward from the fuel filter. Before you remove the pump, take off both negative battery cables from the batteries and clean up the transfer pump and its fuel lines. Now, take out the starter motor and put a drain pan below the pump. Open the fuel line quick-connect at the end of the pump, then remove the top bracket bolt and both of the front and rear banjo bolts. Disconnect the wiring at the side of the pump and remove the three nuts to take out the pump from your car. First, fit new gaskets to the line at the fuel supply support bracket and the banjo bolt at the pump's rear. Make sure you don't tighten the banjo bolt yet. Repeat these steps as for the front side of the pump. Install three new gaskets on the fuel line and banjo bolt, place the three pump studs in the mounting bracket and fit the three nuts. Place the bracket, make sure it's only secure for now and then torque the pump nuts to 12 Nm (9 ft. lbs.), the banjo bolts to 24 Nm (18 ft. lbs.) and the bracket bolt to 12 Nm (9 ft. lbs.) when done. Plug in the electrical connector into the pump and then fasten the quick-connect fitting from the fuel line to the rear of the pump. Reinstall the starter motor, reconnect both of the negative battery cables, bleed air at the side fuel supply line of the fuel injection pump and start the engine to look for any leaks.

OEM Dodge Ram 3500 Fuel Pump

Gas Pump

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

38 Fuel Pumps found

View related parts
Dodge Ram 3500 Fuel Pump Part Number: 68079472AA
$428.48 MSRP: $645.00
You Save: $216.52 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Electric Fuel Pump; Fuel Pump Module Assembly; Fuel Sending Unit; Fuel Pump Module; Fuel Pump Assembly; Module Kit Fuel Pump/Level Unit Package Contain: Fuel Pump Module Sending Unit And O - Ring
- Replaces: RL079472AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2010 Dodge Ram 3500 | Laramie, SLT, ST | 6 Cyl 6.7 L DIESEL
View related parts
Dodge Ram 3500 Fuel Pump Part Number: 4897668AI
$346.94 MSRP: $485.00
You Save: $138.06 (29%)
ADD TO CART
Product Specifications
- Other Name: Module Kit - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Fuel Sending Unit; Fuel Pump Module; Fuel Pump Assembly
- Replaces: 4897668AF, 4897668AH, 4897668AD, 4897668AG, 4897668AE
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1998-2002 Dodge Ram 3500 | Base | 5.9L L6, 6 Cyl 5.9 L DIESEL
View related parts
Dodge Ram 3500 Fuel Pump Part Number: 68001958AB
$351.13 MSRP: $529.00
You Save: $177.87 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Electric Fuel Pump; Fuel Pump Assembly; Fuel Sending Unit; Module Package Fuel Pump/Level Unit
- Replaces: 5104696AB, RL001958AB
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2005-2008 Dodge Ram 3500 | Laramie, SLT, Sport, ST, SXT | 5.7L V8, 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Part Number: RL134554AF
$406.17 MSRP: $590.00
You Save: $183.83 (32%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Pump Module Assembly; Fuel Pump Assembly; Fuel Sending Unit
- Replaced by: 5134554AF
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2007-2009 Dodge Ram 3500 | Laramie, SLT, ST, SXT, Sport | 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Part Number: RL104697AC
$310.31 MSRP: $393.38
You Save: $83.07 (22%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Package - Fuel Pump/Level Unit; Electric Fuel Pump Module Assembly; Fuel Sending Unit.
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2004 Dodge Ram 3500 | Laramie, SLT, ST | 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Transfer Pump Part Number: 5015723AC
$165.42 MSRP: $244.00
You Save: $78.58 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Pump - Fuel; Electric Fuel Pump
- Replaces: 5015723AB
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2000-2002 Dodge Ram 3500 | Base | 6 Cyl 5.9 L DIESEL
View related parts
Dodge Ram 3500 Fuel Transfer Pump Part Number: 5015553AA
$214.14 MSRP: $315.00
You Save: $100.86 (33%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Pump - Fuel; Electric Fuel Pump; Fuel Lift Pump
- Replaced by: 5080885AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1998-1999 Dodge Ram 3500 | Base | 6 Cyl 5.9 L DIESEL
View related parts
Dodge Ram 3500 Fuel Pump Part Number: 4863888AB
$259.46 MSRP: $382.00
You Save: $122.54 (33%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Module - Fuel; Fuel Pump Module Assembly; Fuel Pump Assembly; Fuel Level Sensor; Fuel Sending Unit; Fuel Pump Module; Fuel Gauge Sending Unit
- Replaced by: 4863888AF
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1995 Dodge Ram 3500 | Base
View related parts
Dodge Ram 3500 Fuel Pump Part Number: RL143160AB
$273.89 MSRP: $406.00
You Save: $132.11 (33%)
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Electric Fuel Pump Assembly; Fuel Sending Unit.
- Replaces: 5143160AB, 68002062AB, 68003465AA, 5143160AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2005-2009 Dodge Ram 3500 | Laramie, SLT, Sport, ST, SXT, TRX4 | 5.9L L6, 6 Cyl 5.9 L DIESEL, 6 Cyl 6.7 L DIESEL, 6.7L L6
View related parts
Dodge Ram 3500 Fuel Pump Part Number: 68004489AA
$325.17 MSRP: $484.00
You Save: $158.83 (33%)
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Fuel Pump Assembly; Fuel Sending Unit; Module Package Fuel Pump/Level Unit
- Replaced by: 68004489AB
- Replaces: RL004489AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2007-2008 Dodge Ram 3500 | Laramie, SLT, ST, SXT, Sport | 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Part Number: 5134555AA
$485.18 MSRP: $705.00
You Save: $219.82 (32%)
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Electric Fuel Pump; Fuel Pump Assembly; Module Package Fuel Pump/Level Unit
- Replaces: RL134555AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2004-2005 Dodge Ram 3500 | Laramie, SLT, ST | 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Assembly Part Number: 4897426AE
Product Specifications
- Other Name: Module Package - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Electric Fuel Pump; Fuel Pump
- Replaces: 4897426AC, 4897426AD, 4897426AB
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-1997 Dodge Ram 3500 | Base | 10 Cyl 8.0 L GAS, 8 Cyl 5.9 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Part Number: 4897426AD
Product Specifications
- Other Name: Module Package - Fuel Pump/Level Unit; Fuel Pump Assembly; Electric Fuel Pump; Fuel Level Sensor.; Fuel Gauge Sending Unit
- Replaced by: 4897426AE
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-1997 Dodge Ram 3500 | Base | 10 Cyl 8.0 L GAS, 8 Cyl 5.9 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Part Number: RL086594AA
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Electric Fuel Pump; Fuel Pump Module Assembly; Fuel Pump Assembly
- Replaces: 68086594AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2010 Dodge Ram 3500 | Laramie, SLT, ST, SXT | 6 Cyl 6.7 L DIESEL
View related parts
Dodge Ram 3500 Fuel Pump Part Number: 5134554AE
$186.95 MSRP: $277.00
You Save: $90.05 (33%)
Product Specifications
- Other Name: Module Package - Fuel Pump/Level Unit; Electric Fuel Pump Assembly; Fuel Sending Unit
- Replaces: 5134554AD, 5134554AC
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2004-2008 Dodge Ram 3500 | Laramie, SLT, Sport, ST, SXT | 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Transfer Pump Part Number: 68044569AA
$211.87 MSRP: $311.00
You Save: $99.13 (32%)
Product Specifications
- Other Name: Pump - Fuel; Mechanical Fuel Pump; Mechanical Pump; Fuel Lift Pump; Fuel Pump
- Replaces: 5012209AB, 5012209AC
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1998 Dodge Ram 3500 | Base | 6 Cyl 5.9 L DIESEL
View related parts
Dodge Ram 3500 Module - Fuel Pump/Level Unit Part Number: 68003468AC
$564.49 MSRP: $830.00
You Save: $265.51 (32%)
Product Specifications
- Other Name: MODULE-FUEL PUMP/LEVEL UNIT
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2005-2010 Dodge Ram 3500 | Laramie, SLT, Sport, ST, SXT, TRX4 | 5.9L L6, 6 Cyl 5.9 L DIESEL, 6 Cyl 6.7 L DIESEL, 6.7L L6, 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Assembly Part Number: RL086286AC
Product Specifications
- Other Name: Package Part - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Pump Module Assembly; Fuel Pump
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2003 Dodge Ram 3500 | Laramie, SLT, ST | 10 Cyl 8.0 L GAS, 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Part Number: RL011609AA
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Pump Module Assembly; Fuel Pump Assembly
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2007 Dodge Ram 3500 | Laramie, SLT, ST, Sport | 8 Cyl 5.7 L GAS
View related parts
Dodge Ram 3500 Fuel Pump Part Number: 5104698AC
Product Specifications
- Other Name: Module - Fuel Pump/Level Unit; Fuel Pump Module Assembly; Pump Module Assembly; Fuel Pump Assembly; Module Package Fuel Pump/Level Unit
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2007 Dodge Ram 3500 | Laramie, SLT, ST, Sport | 8 Cyl 5.7 L GAS

| Page 1 of 2 |Next >

1-20 of 38 Results

Dodge Ram 3500 Fuel Pump

Choose OEM Fuel Pump that meet Dodge factory standards. Dodge designs and tests every component for precision and durability. Each Fuel Pump follows strict manufacturing steps to lock in quality and fit. If your Dodge Ram 3500 matters to you, OEM parts make the smart choice. You'll get the exact look, feel, and performance you expect. Shop genuine Ram 3500 parts at the highly competitive prices online. Enjoy a manufacturer's warranty, a hassle-free return policy, and rapid delivery. No more guesswork with off brands. Get genuine parts with exact fit and true factory performance. Shop with confidence today at JeepPartsDeal.com.

Fuel Pump in Dodge Ram 3500 is used to deliver fuel from the tank to the engine so as to ensure proper and efficient burning of fuel in the engine chamber. It works by pump and straining the fuel while channeling it to the carburetor or fuel injectors depending on the demand. Dodge Ram 3500 cars mainly feature electrical fuel pump for fuel injection system which is commonly installed within tanks while, previous carburetor cars may use mechanical pump mostly located outside. Through the years, Dodge Ram 3500 has undergone some changes when it comes to the exhaust pumps, shifting from the older mechanical pump, which tends to provide less force and are actually less efficient, and the new electric pumps which offers more force as well as safety mechanisms. These electric pumps are governed by electronic control units and they raise performance and lower emissions and thus are ideal for today's high pressure fuel injection. The changes found in the Fuel Pump of Dodge Ram 3500 vehicles are adjustments in innovation relating to the engine performance.

Dodge Ram 3500 Fuel Pump Parts and Q&A

Fuel Pump
RL134554AF
Q: How to Service the Fuel Pump and Gauge Sender on Dodge Ram 3500?
A:
Before starting to service the fuel gauge sender, make sure the pressure from the fuel system is released, because it may remain at a constant level. Click the red handle to the right and pull the negative cable from the battery. Following this, disconnect and remove the Fuel Tank and blast away all dirt and particles near the opening using compressed air prior to removing the fuel pump module. Make a note of where the arrow is on the top of the fuel pump module. Put the notches in the lock ring on the car using the lock ring remover/installer 9340, then attach a 1/2 inch drive breaker bar to turn the lock ring counterclockwise. Replacing the rubber O-ring seal is necessary whenever you service the fuel pump module. Remove the fuel pump module from the fuel tank and double-check that the float arm is not bent as you do so. Then, throw out the old rubber O-ring seal.
Fuel Transfer Pump
5015723AC
Q: How to Remove and Install a Fuel Pump on Dodge Ram 3500?
A:
As the fuel transfer pump is known as the fuel lift pump, it is located on the left side of the engine and it is below and moving backward from the Fuel Filter. Before you remove the pump, take off both negative battery cables from the batteries and clean up the transfer pump and its fuel lines. Now, take out the starter motor and put a drain pan below the pump. Open the fuel line quick-connect at the end of the pump, then remove the top bracket bolt and both of the front and rear banjo bolts. Disconnect the wiring at the side of the pump and remove the three nuts to take out the pump from your car. First, fit new gaskets to the line at the fuel supply support bracket and the banjo bolt at the pump's rear. Make sure you don't tighten the banjo bolt yet. Repeat these steps as for the front side of the pump. Install three new gaskets on the fuel line and banjo bolt, place the three pump studs in the mounting bracket and fit the three nuts. Place the bracket, make sure it's only secure for now and then torque the pump nuts to 12 Nm (9 ft. lbs.), the banjo bolts to 24 Nm (18 ft. lbs.) and the bracket bolt to 12 Nm (9 ft. lbs.) when done. Plug in the electrical connector into the pump and then fasten the quick-connect fitting from the fuel line to the rear of the pump. Reinstall the starter motor, reconnect both of the negative battery cables, bleed air at the side fuel supply line of the fuel injection pump and start the engine to look for any leaks.