How to Safely Remove and Service a Blend Door Actuator for Front on Dodge Caravan?

If your car has air bags, first stop the air bag system from being active when servicing the air door by pulling out the negative battery cable. Once the cable is removed, wait two minutes to drain the capacitor inside the air bag module. Lift the carpet along the front passenger floor from the dashboard to reveal the recirculation door actuator. After that, take out the HVAC wire harness connector from the recirculation door actuator. Afterward, take out the two screws holding the recirculation door actuator to the air inlet housing and pull out the actuator.

How to Install a Blend Door Actuator on Dodge Caravan?

Resting the actuator on the air housing and, if required, rotating the actuator until the splines on its shaft match those on the nearby pivot shaft. Hold the actuator steady with the two screws and tighten them to 2 Nm (17 in.lbs.). Fit the HVAC wire harness connector into the actuator hole, then put the carpet back up against the dash panel above the passenger side front floor. Afterward, connect the negative battery cable again and use the A/C-heater control to calibrate it.

OEM Dodge Caravan Blend Door Actuator

Air Blend Door Actuator

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

10 Blend Door Actuators found

View related parts
Dodge Caravan Actuator Part Number: 4734058AB
$122.15 MSRP: $194.00
You Save: $71.85 (38%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Actuator - Blend Door; HVAC Heater Blend Door Actuator; HVAC Blend Door Actuator; Actuator Blend Door
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-2000 Dodge Caravan | Base, ES, LE, SE, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS, BATTERY EV (EV/BEV)
View related parts
Dodge Caravan Servo Part Number: 4462218
$65.09 MSRP: $95.75
You Save: $30.66 (33%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Module - Auxiliary A/C & Heater Mode Door Motor; HVAC Heater Blend Door Actuator; Wiring, Auxiliary A/C, Heater; Servo Assembly, Mode Door Motor; Unit, Auxiliary A/C And Heater.
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1991-1994 Dodge Caravan | Base, C/V, ES, LE, SE | 4 Cyl 2.5 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L GAS
View related parts
Dodge Caravan Door Actuator Part Number: 5183151AB
$56.64 MSRP: $84.95
You Save: $28.31 (34%)
ADD TO CART
Product Specifications
- Other Name: Door - Temperature; HVAC Mode Door; Door; Door Temperature Also Used Assembly The Blend Door; Door Temperature
- Replaces: 5183151AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2007 Dodge Caravan | Base, C/V, SE, SXT | 2.4L L4, 3.3L V6, 4 Cyl 2.4 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS
View related parts
Dodge Caravan Actuator, Rear Part Number: 5061099AA
$63.90 MSRP: $94.00
You Save: $30.10 (33%)
Product Specifications
- Other Name: Actuator - A/C And Heater; HVAC Air Inlet Door Actuator, Rear; HVAC Heater Blend Door Actuator; HVAC Blend Door Actuator; Actuator A/C And Heater Serviced With Distribution Housing; Actuator A/C And Heater
- Position: Rear
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2007 Dodge Caravan | Base, C/V, SE, SXT | 4 Cyl 2.4 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS
View related parts
Dodge Caravan Alternator Part Number: 4734026
Product Specifications
- Other Name: Actuator - Mode Control; HVAC Heater Blend Door Actuator; Actuator; Actuator Mode Control See Note; Actuator, Mode Control Door; Actuator Mode Control
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-2000 Dodge Caravan | Base, ES, LE, SE, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS, BATTERY EV (EV/BEV)
View related parts
Dodge Caravan Actuator, Rear Part Number: 4885465AA
Product Specifications
- Other Name: Actuator - A/C And Heater; HVAC Air Inlet Door Actuator, Rear; HVAC Heater Blend Door Actuator; HVAC Blend Door Actuator; Actuator A/C And Heater
- Position: Rear
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2005 Dodge Caravan | Base, C/V, Ec, SE, SXT, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS
View related parts
Dodge Caravan Actuator Part Number: 4734225AB
Product Specifications
- Other Name: Actuator - Recirculation Door; HVAC Heater Blend Door Actuator; Actuator Recirculation Door
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-2000 Dodge Caravan | Base, ES, LE, SE, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS, BATTERY EV (EV/BEV)
View related parts
Dodge Caravan Dehydrator Part Number: 4798589
Product Specifications
- Other Name: Bracket Assembly - A/C; Drier Desiccant Element; Actuator; Drier
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1991-1992, 1984-1988 Dodge Caravan | Base, C/V, ES, LE, SE | 4 Cyl 2.2 L GAS, 4 Cyl 2.5 L GAS, 4 Cyl 2.6 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L GAS
View related parts
Dodge Caravan Servo Part Number: 4644768
Product Specifications
- Other Name: Servo - With Linkage (Mode; HVAC Heater Blend Door Actuator; Servo, Mode Door
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1995 Dodge Caravan | Base, C/V, ES, LE, SE | 4 Cyl 2.5 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L GAS
View related parts
Dodge Caravan Actuator Part Number: 4734047AB
Product Specifications
- Other Name: Actuator - Mode Control; Actuator Mode Control
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-2000 Dodge Caravan | Base, ES, LE, SE, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS, BATTERY EV (EV/BEV)

Dodge Caravan Blend Door Actuator

Choose OEM Blend Door Actuator that meet Dodge factory standards. Dodge designs and tests every component for precision and durability. Each Blend Door Actuator follows strict manufacturing steps to lock in quality and fit. If your Dodge Caravan matters to you, OEM parts make the smart choice. You'll get the exact look, feel, and performance you expect. Shop genuine Caravan parts at the highly competitive prices online. Enjoy a manufacturer's warranty, a hassle-free return policy, and rapid delivery. No more guesswork with off brands. Get genuine parts with exact fit and true factory performance. Shop with confidence today at JeepPartsDeal.com.

The Dodge Caravan Blend Door Actuator serves as a vital system component which controls HVAC functions in Dodge Caravan vehicles because of its well-known reliability and performance strength. An electric motor controls air movement through different vents to properly blend hot and cold air which enables the cabin to achieve its aimed temperature level effectively. The Dodge Caravan Blend Door Actuator guides air flow properly so the cabin stays Smooth from unnecessary warm air thus creating better comfort and enhanced safety. The Dodge Caravan Blend Door Actuator demonstrates model versatility through its adaptable design yet executes a single basic temperature control function across all version types. Your Dodge Caravan will encounter major driving experience problems when the Blend Door Actuator fails to function properly since it controls air temperature and airflow direction. The Dodge Caravan Blend Door Actuator identifies itself in the automotive sector because its durable structure plus dependable functionality provides passengers with comfort even during unpredictable weather. This actuator demonstrates strong functionality by adapting to unique requirements that apply to various the automaker model vehicle models thus promoting safe and efficient vehicle operation. The car Blend Door Actuator showcases the high-quality innovative approach which has secured the car popularity among families together with individual drivers.

Dodge Caravan Blend Door Actuator Parts and Q&A

Door Actuator
5183151AB
Q: How to Safely Remove and Service a Blend Door Actuator for Front on Dodge Caravan?
A:
If your car has air bags, first stop the air bag system from being active when servicing the air door by pulling out the negative battery cable. Once the cable is removed, wait two minutes to drain the capacitor inside the air bag module. Lift the carpet along the front passenger floor from the dashboard to reveal the recirculation door actuator. After that, take out the HVAC wire harness connector from the recirculation door actuator. Afterward, take out the two screws holding the recirculation door actuator to the air inlet housing and pull out the actuator.
Actuator, Rear
5061099AA
Q: How to Install a Blend Door Actuator on Dodge Caravan?
A:
Resting the actuator on the air housing and, if required, rotating the actuator until the splines on its shaft match those on the nearby pivot shaft. Hold the actuator steady with the two screws and tighten them to 2 Nm (17 in.lbs.). Fit the HVAC wire harness connector into the actuator hole, then put the carpet back up against the dash panel above the passenger side front floor. Afterward, connect the negative battery cable again and use the A/C-heater control to calibrate it.