How to Service and Repair a Brake Disc on Dodge Grand Caravan?

Before servicing or repairing your front brake disc, jack your car using either jackstands or a frame contact type hoist. Take off the front wheel and tire and then unscrew the two bolts that hold the disc brake caliper adapter and brake caliper to the steering knuckle. Be sure to slowly disconnect the caliper and adapter from the steering knuckle as a single piece; then hang it out of harm's way with wire or a bungee cord so it doesn't apply stress on the hose. After that, unhook any retainers from the wheel mounting studs and take the brake disc straight off them. Make sure the disc is back on the hub and the bearing before lining up the brake caliper and adapter over the disc. Place the adapter above the steering knuckle and fasten it in by using the two mounting bolts and turning them to 169 Nm (125 ft. lbs.). After inserting the wheel and tire, begin tightening the wheel nuts halfway following the right sequence, then go back and tighten them further to the specified 135 Nm (100 ft. lbs.). Place the vehicle back onto the ground.

How to Remove and Replace a Front Brake Disc on Dodge Grand Caravan?

The first thing to do with the front brake rotor is to instal them without removing and replacing and inspect the disc brake pads beforehand. Clean the hub face in order to get any dirt or rust off where the rotor mounts. Then install the brake rotor to the studs that press against the hub and bearing. Position the brake rotor and knuckle then position the disc brake caliper and adapter bracket assembly over the brake rotor. Mount two caliper adapter bracket mounting bolts, inboard and outboard, over the top of the knuckle and tighten to 169 Nm (125 ft. lbs.). Then installation of the tire and wheel assembly can be done and it is tightened down to 135 Nm (100 ft. lbs.) for the wheel mounting nuts. Pump the brake pedal several times to set the pads to the brake rotor while lower the vehicle. Next, readjust the brake fluid level in the reservoir if required and do a road test, bringing the car to a halt numerous times to make sure the brake pads contact the rotor.

OEM Dodge Grand Caravan Brake Disc

Disc Rotor

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

15 Brake Discs found

View related parts
Dodge Grand Caravan Rotor, Front Part Number: 4721830AC
$120.59 MSRP: $221.00
You Save: $100.41 (46%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Rotor, Front; Disc Brake Hardware Kit; Disc Brake Rotor; Brake Rotor; Brake Disc
- Position: Front
- Replaces: 5019981AB
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2007 Dodge Grand Caravan | Anniversary Edition, Base, C/V, EL, ES, EX, SE, SE Plus, SXT, Sport | 3.3L V6, 3.8L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Rotor, Rear Part Number: 4721996AB
$64.63 MSRP: $97.45
You Save: $32.82 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Rotor, Rear; Rotor Brake Rear; Disc Brake Rotor; Brake Rotor
- Position: Rear
- Replaces: 4721677AA, 4721996AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008-2018 Dodge Grand Caravan | American Value Package, C/V, Crew, Express, GT, Mainstreet, R/T, SE, SE 30th Anniversary Edition, SE Plus, SXT, SXT 30th Anniversary Edition | 3.3L V6, 3.6L V6, 3.8L V6, 4.0L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Dodge Grand Caravan Rotor, Front Part Number: 4779783AB
$80.84 MSRP: $121.00
You Save: $40.16 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Rotor, Front; Disc Brake Hardware Kit; Rotor Brake Front; Brake Rotor
- Position: Front
- Replaces: 4721933AB, 4779783AA, 4721995AB
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008-2017 Dodge Grand Caravan | American Value Package, C/V, Crew, Express, GT, Mainstreet, R/T, SE, SE 30th Anniversary Edition, SE Plus, SXT, SXT 30th Anniversary Edition | 3.3L V6, 3.6L V6, 3.8L V6, 4.0L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Dodge Grand Caravan Rotor, Front Part Number: 4779712AB
$99.30 MSRP: $152.00
You Save: $52.70 (35%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Rotor, Front; Disc Brake Hardware Kit; Rotor Brake Front; Disc Brake Rotor; Brake Rotor
- Position: Front
- Replaces: 4779712AA, 68192969AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2012-2020 Dodge Grand Caravan | American Value Package, Crew, GT, R/T, SE, SE 30th Anniversary Edition, SE Plus, SXT, SXT 30th Anniversary Edition | 3.6L V6, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Dodge Grand Caravan Rotor Part Number: 4721820AE
$85.28 MSRP: $188.00
You Save: $102.72 (55%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Hardware Kit; Disc Brake Rotor; Brake Rotor; Brake Disc; Rotor Brake
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-2000 Dodge Grand Caravan | Base, ES, LE, SE, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L CNG, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Rotor, Rear Part Number: 4779713AB
$83.88 MSRP: $130.00
You Save: $46.12 (36%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Rotor, Rear; Disc Brake Hardware Kit; Rotor Brake Rear; Disc Brake Rotor; Brake Rotor
- Position: Rear
- Replaces: 4779713AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2012-2020 Dodge Grand Caravan | American Value Package, Crew, GT, R/T, SE, SE 30th Anniversary Edition, SE Plus, SXT, SXT 30th Anniversary Edition | 3.6L V6, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Dodge Grand Caravan Rotor, Front Part Number: 4721820AG
$138.13 MSRP: $207.00
You Save: $68.87 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Rotor, Front; Disc Brake Hardware Kit; Brake Disc; Rotor Brake; Disc Brake Rotor; Brake Rotor
- Position: Front
- Replaces: 4721820AF
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2007 Dodge Grand Caravan | Anniversary Edition, Base, C/V, EL, ES, EX, SE, SE Plus, SXT, Sport | 3.3L V6, 3.8L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Rotor - Brake Part Number: 68227781AC
$173.35 MSRP: $260.00
You Save: $86.65 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: ROTOR-BRAKE
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2014-2017 Dodge Grand Caravan | American Value Package, GT, R/T, SE, SE 30th Anniversary Edition, SE Plus, SXT, SXT 30th Anniversary Edition | 3.6L V6, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Dodge Grand Caravan Rotor, Front Part Number: 4721995AA
$83.33 MSRP: $124.00
You Save: $40.67 (33%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Brake; Disc Brake Rotor, Front; Disc Brake Hardware Kit; Rotor Brake Front; Brake Rotor
- Position: Front
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2010 Dodge Grand Caravan | C/V, SE, SXT | 6 Cyl 3.3 L FLEX, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Dodge Grand Caravan Rotor, Front Part Number: 68032944AB
$102.31 MSRP: $151.00
You Save: $48.69 (33%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Rotor, Front; Disc Brake Hardware Kit; Disc Brake Rotor; Brake Rotor
- Position: Front
- Replaces: 68032944AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2008-2011 Dodge Grand Caravan | C/V, Crew, Express, Mainstreet, R/T, SE, SXT | 3.3L V6, 3.6L V6, 3.8L V6, 4.0L V6, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS, 6 Cyl 3.8 L GAS, 6 Cyl 4.0 L GAS
View related parts
Dodge Grand Caravan Rotor, Rear Part Number: 68227800AB
$109.05 MSRP: $162.00
You Save: $52.95 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Rotor, Rear; Rotor Brake Rear; Brake Rotor
- Position: Rear
- Replaces: 68227800AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2014-2016 Dodge Grand Caravan | American Value Package, R/T, SE, SE Plus, SXT | 3.6L V6, 6 Cyl 3.6 L FLEX, 6 Cyl 3.6 L GAS
View related parts
Dodge Grand Caravan Rotor, Rear Part Number: 4721023AG
$62.94 MSRP: $94.10
You Save: $31.16 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Disc - Brake; Disc Brake Rotor, Rear; Disc Brake Rotor; Brake Rotor
- Position: Rear
- Replaces: 4721023AE, 4721023AF
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1997-2007 Dodge Grand Caravan | Anniversary Edition, Base, C/V, EL, ES, EX, LE, SE, SE Plus, SXT, Sport | 3.3L V6, 3.8L V6, 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Rotor Part Number: 4509340
Product Specifications
- Other Name: Rotor - Front Wheel Brake - Finished; Disc Brake Hardware Kit; Disc Brake Rotor; Brake Rotor; Brake Disc; Disc, Front Wheel Brake (11.00" Diameter)
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1991-1995 Dodge Grand Caravan | Base, ES, LE, SE | 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Rotor Part Number: 4683259AC
Product Specifications
- Other Name: Rotor - Brake; Disc Brake Hardware Kit; Brake Rotor
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1996-2000 Dodge Grand Caravan | Base, ES, LE, SE, Sport | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L CNG, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS
View related parts
Dodge Grand Caravan Brake Rotor Part Number: 4383968
Product Specifications
- Other Name: Disc - Front Wheel Brake - Finish; Disc Brake Hardware Kit; Rotor; Disc, Front Wheel Brake (10.25" Diameter); Disc, Front Wheel Brake (11.00" Diameter); Disc, Front Wheel Brake
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 1991-1995 Dodge Grand Caravan | Base, ES, LE, SE | 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L GAS, 6 Cyl 3.8 L GAS

Dodge Grand Caravan Brake Disc

Choose OEM Brake Disc that meet Dodge factory standards. Dodge designs and tests every component for precision and durability. Each Brake Disc follows strict manufacturing steps to lock in quality and fit. If your Dodge Grand Caravan matters to you, OEM parts make the smart choice. You'll get the exact look, feel, and performance you expect. Shop genuine Grand Caravan parts at the highly competitive prices online. Enjoy a manufacturer's warranty, a hassle-free return policy, and rapid delivery. No more guesswork with off brands. Get genuine parts with exact fit and true factory performance. Shop with confidence today at JeepPartsDeal.com.

The Brake Disc of the Dodge Grand Caravan is a vital component of the car's disc brake making it the braking component that necessitates the frictional surface for optimum braking ability. Attached to the axle or the hub, the rotor revolves around with the wheel where hydraulic pressure from the brake calipers squeezes the friction pads onto it, making the vehicle slow or stop. The Dodge Grand Caravan usually comes with cast iron rotors, and they might include some vents to increase the cooling ability especially as you travers the highways moving from one family destination to the other. Various innovations in the style of Brake Disc have been crafted over the years, these being the solid and the vented kind, though the latter is commonly fitted in the front owing to its unique properties in the heat dissipation mechanism. This is due to the fact that abnormal conditions such as scoring, warping and high runout affect the braking capability of the rail. It is therefore important to take time periodically inspect the Brake Disc and in case the disk shows signs of wearing, it has to be replaced as soon as possible in the Dodge Grand Caravan.

Dodge Grand Caravan Brake Disc Parts and Q&A

Rotor, Front
4721830AC
Q: How to Service and Repair a Brake Disc on Dodge Grand Caravan?
A:
Before servicing or repairing your front brake disc, jack your car using either jackstands or a frame contact type hoist. Take off the front wheel and tire and then unscrew the two bolts that hold the disc Brake Caliper adapter and brake caliper to the Steering Knuckle. Be sure to slowly disconnect the caliper and adapter from the steering knuckle as a single piece; then hang it out of harm's way with wire or a bungee cord so it doesn't apply stress on the hose. After that, unhook any retainers from the wheel mounting studs and take the brake disc straight off them. Make sure the disc is back on the hub and the bearing before lining up the brake caliper and adapter over the disc. Place the adapter above the steering knuckle and fasten it in by using the two mounting bolts and turning them to 169 Nm (125 ft. lbs.). After inserting the wheel and tire, begin tightening the wheel nuts halfway following the right sequence, then go back and tighten them further to the specified 135 Nm (100 ft. lbs.). Place the vehicle back onto the ground.
Rotor, Front
4779783AB
Q: How to Remove and Replace a Front Brake Disc on Dodge Grand Caravan?
A:
The first thing to do with the front brake rotor is to instal them without removing and replacing and inspect the disc Brake Pads beforehand. Clean the hub face in order to get any dirt or rust off where the rotor mounts. Then install the brake rotor to the studs that press against the hub and bearing. Position the brake rotor and knuckle then position the disc Brake Caliper and adapter bracket assembly over the brake rotor. Mount two caliper adapter bracket mounting bolts, inboard and outboard, over the top of the knuckle and tighten to 169 Nm (125 ft. lbs.). Then installation of the tire and wheel assembly can be done and it is tightened down to 135 Nm (100 ft. lbs.) for the wheel mounting nuts. Pump the brake pedal several times to set the pads to the brake rotor while lower the vehicle. Next, readjust the brake fluid level in the reservoir if required and do a road test, bringing the car to a halt numerous times to make sure the brake pads contact the rotor.