How to Safely Remove and Service an Air Bag on Chrysler PT Cruiser?

You should first open the hood, detach the negative battery cable and wait for two minutes to ensure the air bag reserve capacitor is discharged before removal. Set the steering column in the highest point possible. Take a small piece of trim stick or anything similar and gently open the upper corners of the under column cover on both sides of the steering column. To release the loop tabs, first pull on the under steering column cover and then reach down through the column to push on the loop at the bottom to come free from the reinforcement tab. Unscrew one screw from the end cap from the left side of the instrument panel, unsnap the cap and disconnect the power mirror electrical connector if you have one. Remove the two upper screws that fix the knee blocker air bag trim cover to the column, one from each side. Using your hand through the access panel beside the knee blocker air bag, release the hook and loop straps on the upper side of the knee blocker air bag. The next step is to loosen the two torx bolts securing the knee blocker air bag to the instrument panel, as the knee blocker air bag trim cover will come off the hooks along the side at this point.

How to Install an Air Bag for Knee Protection on Chrysler PT Cruiser?

The first step is to link the electrical connector from the knee blocker air bag. Next, slide the lower hook channels through the knee blocker air bag trim cover and place the cover in the instrument panel cavity. Fit both knee blocker air bag screws and tighten each one to 10.5 Nm (95 in. lbs.). Through the instrument panel hole, attach the upper hook and loop retainers that hold the knee blocker air bag trim cover in place. Insert one screw on each side through the trim cover onto the column. If the power mirror is installed, connect the corresponding electrical connector and then snap the instrument panel end cap in tightly. Put an end cap retaining screw into each run of tubing. After that, tuck the bottom of the under steering column cover into the top of the knee blocker air bag trim cover, line up and hook the Velcro and connect the outer edges. Never connect the negative battery cable until the system test has been performed. This will prevent injuries.

OEM Chrysler PT Cruiser Air Bag

Air Bag Module

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

15 Air Bags found

View related parts
Chrysler PT Cruiser Side Air Bag, Front Part Number: 4645986AC
$132.56 MSRP: $196.00
You Save: $63.44 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Airbag - Seat; Seat Air Bag, Front; Air Bag Seat
- Position: Front
- Replaces: 4645986AB
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2009-2010 Chrysler PT Cruiser | Base, Classic, Couture Edition, LX, Limited, Touring | 2.4L L4, 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Driver Air Bag, Beige/Taupe, Driver Side Part Number: ZE64DKAAF
$334.24 MSRP: $492.00
You Save: $157.76 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Airbag - Driver; Steering Wheel Air Bag
- Position: Driver Side
- Replaces: ZE64DKAAC, ZE64DKAAD, ZE64DKAAE
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006 Chrysler PT Cruiser | Base, GT, Limited, Street Cruiser, Touring | 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Driver Inflator Module, Beige/Taupe, Driver Side Part Number: ZE64DK5AF
$405.33 MSRP: $590.00
You Save: $184.67 (32%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Airbag - Driver; Steering Wheel Air Bag; Driver Air Bag; Air Bag Driver
- Position: Driver Side
- Replaces: ZE64DK5AE
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2009 Chrysler PT Cruiser | Base, GT, LX, Limited, Street Cruiser, Touring | 2.4L L4, 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Passenger Air Bag, Upper Passenger Side Part Number: 52029311AD
$569.07 MSRP: $829.00
You Save: $259.93 (32%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Airbagg - Passenger; Instrument Panel Air Bag, Upper; Passenger Inflator Module; Air Bag Passenger
- Position: Upper Passenger Side
- Replaces: 52029311AC, 52029311AB
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2010 Chrysler PT Cruiser | Base, Classic, Couture Edition, GT, LX, Limited, Street Cruiser, Touring | 2.4L L4, 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Driver Inflator Module, Gray, Driver Side Part Number: ZE64XDHAF
$1036.23 MSRP: $1515.00
You Save: $478.77 (32%)
ADD TO CART
Product Specifications
- Other Name: Airbag - Driver; Steering Wheel Air Bag; Driver Air Bag; Air Bag Driver
- Position: Driver Side
- Replaces: ZE64XDHAE
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2010 Chrysler PT Cruiser | Base, Classic, Couture Edition, GT, LX, Limited, Touring | 2.4L L4, 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Driver Inflator Module, Taupe, Driver Side Part Number: WG26WL8AD
Product Specifications
- Other Name: Airbag - Driver; Steering Wheel Air Bag; Driver Air Bag; Air Bag Driver
- Position: Driver Side
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2003-2005 Chrysler PT Cruiser | Base, Dream Cruiser, GT, Limited, Street Cruiser, Touring | 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Passenger Air Bag, Upper Passenger Side Part Number: 4664322AB
Product Specifications
- Other Name: Airbag - Passenger; Instrument Panel Air Bag, Upper; Passenger Inflator Module; Air Bag Passenger
- Position: Upper Passenger Side
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2003-2005 Chrysler PT Cruiser | Base, Dream Cruiser, GT, Limited, Street Cruiser, Touring | 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Side Impact Inflator Module, Front Driver Side Part Number: 4664289AA
Product Specifications
- Other Name: Airbag - Seat; Seat Air Bag, Front Left; Side Air Bag; Air Bag Seat
- Position: Front Driver Side
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2002-2005 Chrysler PT Cruiser | Base, Dream, Dream Cruiser, GT, Limited, Street Cruiser, Touring | 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Passenger Air Bag, Upper Passenger Side Part Number: 4664252AF
Product Specifications
- Other Name: Airbag - Passenger; Instrument Panel Air Bag, Upper; Passenger Inflator Module
- Position: Upper Passenger Side
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2002 Chrysler PT Cruiser | Base, Dream, Limited, Touring | 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser SDM Module, Front Passenger Side Part Number: 4645946AA
Product Specifications
- Other Name: Seat; Seat Air Bag, Front Right; Side Impact Inflator Module; Side Air Bag; Side Sensor; Air Bag Seat
- Position: Front Passenger Side
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2005 Chrysler PT Cruiser | Base, Dream, Dream Cruiser, GT, Limited, Street Cruiser, Touring | 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Control Module, Front Part Number: 4645986AA
Product Specifications
- Other Name: Airbag - Seat; Seat Heater Control Module, Front; Seat Heater Control Module; Seat Air Bag, Front; Side Impact Inflator Module; Side Air Bag; Module; Air Bag Seat
- Position: Front
- Replaces: 5175666AA, 52029313AA, 52029312AA
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006-2010 Chrysler PT Cruiser | Base, Classic, Couture Edition, GT, LX, Limited, Street Cruiser, Touring | 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Side Impact Inflator Module, Front Passenger Side Part Number: 5293228AE
Product Specifications
- Other Name: Module - Side Impact Right; Seat Air Bag, Front Right; Side Air Bag
- Position: Front Passenger Side
- Replaces: 5293228AD
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2003 Chrysler PT Cruiser | Base, Dream, GT, Limited, Touring | 2.4L L4, 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Side Impact Inflator Module, Front Driver Side Part Number: 5293229AE
Product Specifications
- Other Name: Module - Side Impact Left; Seat Air Bag, Front Left; Side Air Bag
- Position: Front Driver Side
- Replaces: 5293229AD
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2001-2003 Chrysler PT Cruiser | Base, Dream, GT, Limited, Touring | 2.4L L4, 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Driver Air Bag, Gray, Driver Side Part Number: ZE64BDAAF
Product Specifications
- Other Name: Airbag - Driver; Steering Wheel Air Bag
- Position: Driver Side
- Replaces: ZE64BDAAD, ZE64BDAAE, ZE64BDAAC
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2006 Chrysler PT Cruiser | Base, GT, Limited, Street Cruiser, Touring | 4 Cyl 2.4 L GAS
View related parts
Chrysler PT Cruiser Driver Inflator Module, Slate Gray, Driver Side Part Number: WG26XDVAD
Product Specifications
- Other Name: Airbag - Driver; Steering Wheel Air Bag; Driver Air Bag; Air Bag Driver
- Position: Driver Side
- Replaces: WG26XDVAC
- Warranty: This genuine part is guaranteed by Mopar's factory warranty.
Fits the following Vehicles:
- 2003-2005 Chrysler PT Cruiser | Base, Dream Cruiser, GT, Limited, Street Cruiser, Touring | 2.4L L4, 4 Cyl 2.4 L GAS

Chrysler PT Cruiser Air Bag

Choose OEM Air Bag that meet Chrysler factory standards. Chrysler designs and tests every component for precision and durability. Each Air Bag follows strict manufacturing steps to lock in quality and fit. If your Chrysler PT Cruiser matters to you, OEM parts make the smart choice. You'll get the exact look, feel, and performance you expect. Shop genuine PT Cruiser parts at the highly competitive prices online. Enjoy a manufacturer's warranty, a hassle-free return policy, and rapid delivery. No more guesswork with off brands. Get genuine parts with exact fit and true factory performance. Shop with confidence today at JeepPartsDeal.com.

Chrysler PT Cruiser Air Bag Parts and Q&A

Driver Inflator Module, Gray, Driver Side
ZE64XDHAF
Q: How to Safely Remove and Service an Air Bag on Chrysler PT Cruiser?
A:
You should first open the hood, detach the negative Battery Cable and wait for two minutes to ensure the air bag reserve capacitor is discharged before removal. Set the steering column in the highest point possible. Take a small piece of trim stick or anything similar and gently open the upper corners of the under column cover on both sides of the steering column. To release the loop tabs, first pull on the under Steering Column Cover and then reach down through the column to push on the loop at the bottom to come free from the reinforcement tab. Unscrew one screw from the end cap from the left side of the instrument panel, unsnap the cap and disconnect the power mirror electrical connector if you have one. Remove the two upper screws that fix the knee blocker air bag trim cover to the column, one from each side. Using your hand through the access panel beside the knee blocker air bag, release the hook and loop straps on the upper side of the knee blocker air bag. The next step is to loosen the two torx bolts securing the knee blocker air bag to the instrument panel, as the knee blocker air bag trim cover will come off the hooks along the side at this point.
Passenger Air Bag, Upper Passenger Side
52029311AD
Q: How to Install an Air Bag for Knee Protection on Chrysler PT Cruiser?
A:
The first step is to link the electrical connector from the knee blocker air bag. Next, slide the lower hook channels through the knee blocker air bag trim cover and place the cover in the instrument panel cavity. Fit both knee blocker air bag screws and tighten each one to 10.5 Nm (95 in. lbs.). Through the instrument panel hole, attach the upper hook and loop retainers that hold the knee blocker air bag trim cover in place. Insert one screw on each side through the trim cover onto the column. If the power mirror is installed, connect the corresponding electrical connector and then snap the instrument panel end cap in tightly. Put an end cap retaining screw into each run of tubing. After that, tuck the bottom of the under Steering Column Cover into the top of the knee blocker air bag trim cover, line up and hook the Velcro and connect the outer edges. Never connect the negative battery cable until the system test has been performed. This will prevent injuries.

Related Chrysler PT Cruiser Parts

Browse Chrysler PT Cruiser Air Bag by Years

2010 2009 2008 2007 2006 2005 2004 2003 2002 2001

OEM Chrysler PT Cruiser Air Bag

15 Air Bags found

Chrysler PT Cruiser Side Air Bag, Front Part Number: 4645986AC

Chrysler PT Cruiser Driver Air Bag, Beige/Taupe, Driver Side Part Number: ZE64DKAAF

Chrysler PT Cruiser Driver Inflator Module, Beige/Taupe, Driver Side Part Number: ZE64DK5AF

Chrysler PT Cruiser Passenger Air Bag, Upper Passenger Side Part Number: 52029311AD

Chrysler PT Cruiser Driver Inflator Module, Gray, Driver Side Part Number: ZE64XDHAF

Chrysler PT Cruiser Driver Inflator Module, Taupe, Driver Side Part Number: WG26WL8AD

Chrysler PT Cruiser Passenger Air Bag, Upper Passenger Side Part Number: 4664322AB

Chrysler PT Cruiser Side Impact Inflator Module, Front Driver Side Part Number: 4664289AA

Chrysler PT Cruiser Passenger Air Bag, Upper Passenger Side Part Number: 4664252AF

Chrysler PT Cruiser SDM Module, Front Passenger Side Part Number: 4645946AA

Chrysler PT Cruiser Control Module, Front Part Number: 4645986AA

Chrysler PT Cruiser Side Impact Inflator Module, Front Passenger Side Part Number: 5293228AE

Chrysler PT Cruiser Side Impact Inflator Module, Front Driver Side Part Number: 5293229AE

Chrysler PT Cruiser Driver Air Bag, Gray, Driver Side Part Number: ZE64BDAAF

Chrysler PT Cruiser Driver Inflator Module, Slate Gray, Driver Side Part Number: WG26XDVAD

Chrysler PT Cruiser Air Bag

Chrysler PT Cruiser Air Bag Parts and Q&A

Related Chrysler PT Cruiser Parts

Browse Chrysler PT Cruiser Air Bag by Years